Combustion gas treatment and a malfunction due to gas 2 ton szs fired water tube boiler burner ignition misfire bar: 1, the ignition bar gap interposed carbon residue with oil. 2, ignition rods fragmentation. moist. Leakage. 3, the distance between the ignition does not stick, too long or short. 4, ignition rods Insulation damage, short to ground. 5, ignition cable and transformer failure: cable, connector damage caused by a short circuit during ignition; transformer break or other fault occurs. Gas Burner fails, the action bar ignition misfire following five: Clear, renewal, adjust the distance, change and switching transformer. Second, the gas boiler the ignition spark rod misfiring but the reasons: 1, the disk space ventilation carbon cyclone is blocked, poor ventilation. 2, dirty oil nozzle clogging or wear. 3, the throttle angle is set too small. 4, the firing bar from the leading edge from the oil nozzle tip inappropriate (too protruding or retracted) 5, the first solenoid valve is an oil debris blocking gun (gun small kerosene). 6, oily or too viscous to flow easily clogged or the oil filtration system the valve is not opened, so that insufficient suction pump, oil pressure. 7, the filter pump itself blocked. 8, the oil more water (boiling abnormal noise within the heater). Gas boiler ignition spark rod action but misfiring are: clear; the first washing, such as not renewed; turndown test; adjusting the distance (in 3 ~ 4mm as well); Remove cleaning (cleaning the parts diesel) ; check the pipeline and oil filters, insulation equipment; peripheral screw pump removed, carefully remove the cover inside out net oil, diesel oil immersion; renewal of the test oil. Third, when the gas boiler and turn the fire a small fire normal, off, or flashing the causes of instability: 1, air volume damper setting fire too. 2, oil fires micro switch valve (damper outermost that group) inappropriate setting (set throttle air flow rate is greater than the fire). 3, oleaginous easy to spray viscosity is too high (heavy). 4, and the nozzle plate spacing cyclone inappropriate. 5, fire nozzle worn or dirty. 6, the preliminary fuel tank temperature is too high, so that the steam not smooth oil pump oil feed. 7, gas hot water boiler fuel oil water. When a small fire gas boiler normal and turn the fire extinguished or flashing instability action: Test gradually reduced; heating temperature; adjusting the distance (between 0 ~ 10mm); clean or replace; i.e., set to about 50 deg.] C may be; or drain oil change. Fourth, the noise increases gas boiler burner reasons: 1, cut-off valve is closed or the passage into the fuel shortage, an oil filter blockage. 2, the oil inlet temperature is low, the oil viscosity is too high or the temperature is too high the pump inlet. 3, oil pump failure. 4, fan motor bearing damage. 5, dirty fan impeller. Burner gas treatment increased noise: ① the check valve in the oil line is open, if the oil filter is working properly, the filter cleaning pump itself. ② heating oil or reduce the oil temperature. ③ Replace the oil pump. ④ replace motor or bearings. ⑤ cleaning fan wheel.
What is the main danger steam 2 ton szs fired water tube boiler? The main danger emergency steam boiler 1, surveillance, hazard control boiler steam boiler regular inspection tours, and monitor pressure, water level, temperature and combustion conditions to control the boiler operating conditions. And to take timely measures to ensure safety. 2, the processing operation of the steam boiler in special circumstances: (1) water shortage phenomenon: When the boiler water, the water level below the water table level limits not visible, low water level alarm emits an alarm, bell lights, low interlocking means so that the water level blower, fan, etc. closure operation; boiler exhaust gas temperature rise, a serious lack of water, lake taste top coke production, the door can be seen from the red-hot waterwall tubes, tube deformation or even explosion pipe, can be heard blasting sound, smoke and steam discharged from the door to see the fire door. Treatment: When judged as a serious water shortage, should an emergency shutdown, non-serious water shortage boiler water to the boiler. Immediately stopping the supply of fuel, the wind stops blowing weakened, the front portion of the coal grate furnace Pa, the maximum switch the grate, combustion slag hopper falls quickly, with irrigated off, after extinguishing the fire, stop the wind, open ash door, the door to promote accelerated cooling. Note: Do not feed water to the boiler, shall take measures to prompt blood pressure, prevent the accident, to refrain from watering methods to the furnace fire put out the fire. (2) boiler overpressure phenomenon: a sharp rise in steam pressure, exceeds the allowable working pressure gauge pointer over the "red line", the safety valve, the pressure is still elevated, issued overpressure alarm, steam temperature and steam flow rises cut back. Processing: weakened rapidly burning, manually open the vent valve or safety valve, to increase the water supply, sewage increase (normal water level at this time to keep the boiler), thus reducing the temperature of the boiler water a boiler drum pressure decrease. (3) boiler tube phenomenon: the waterwall tubes blasting significant audible pops or jet sound, until the furnace by the combustion pressure becomes the negative pressure combustion, flue gas and steam and has viewed from the fire door, the door does not close, etc. discharge, although the water supply amount is increased, but difficult to maintain the normal water level and the pressure reduced, the amount of water to abnormally greater than the amount of steam, the exhaust gas temperature decreases, the chimney white smoke, the furnace temperature is reduced, or even extinguished, water flow out of the bottom of the boiler. Treatment: furnace tube rupture is not serious and can maintain the water level when the accident not to expand, may reduce short-term load operation, serious burst pipe and the water level can not be maintained, must be an emergency shutdown. But the wind should not stop, should continue to Sheung Shui, lower wall temperature. Such as: lack of water wall overheating, while burst pipes, emergency shutdown should be prohibited to the boiler feed water, the withdrawal of the furnace over the fire as soon as possible, reducing the furnace temperature, reducing the degree of superheating boiler. (4) steam boilers will produce full of water, such as priming scene of the accident, should take timely and effective measures to eliminate given. (5) boiler operation, in the event when one of the following circumstances, should immediately shutdown :( a) boiler water level below the lowest water level gauge visible edge; (b) increasing water supply and other measures, but the water level continued to decline; (iii ) boiler water level exceeds the highest visible level, the drainage can not see the water level; (iv) to pump all the water system failure or malfunction, not bottled water to the boiler; (e) all of the water table or valve failure; (vi) is set in a stripping all space gauge failure; (vii) damage the boiler element and endanger the safety of operating personnel.
How how electric steam 2 ton szs fired water tube boiler maintenance electric steam boiler maintenance 1, boiler maintenance, must be cut off and must relief. 2, the burner every two months to be removed from the boiler, carefully remove foreign bodies such as dust and soot. Photocell light-receiving surface wipe once a month, fuel filter should always be kept clean and filtering capabilities; carefully clean the filter in the pump, do not break the seal. Oil-burner not idle, so as not to damage the pump. 3, the water level gauge should always be kept clean, rinse the purge valve is opened, the water level in order to ensure a clear day. 4, pulling the safety valve once a day, to prevent rusting failure. 5, electric steam boilers stop running long time, turn off the power, and do maintenance work: (1), dry maintenance, shutdown after the release came out water, dirt clean the furnace, with a slow fire the burner drying pot (burning time not too long, to avoid damage to the boiler), then all of the drained gas boiler, all pipe valve closed, checked every three months. (2), wet maintenance for a period not exceeding one month shutdown of the boiler, furnace shutdown after water release, discharge and clean fill with water, cut off the power, close the valve.
Harbin City, Heilongjiang Province will continue to promote Blue Sky Battle Action Plan to increase emissions control work, it intends to phase out coal-fired 2 ton szs fired water tube boilers 1201 Taiwan, in accordance with national and provincial requirements, with the distribution area are classified Shi policy. Wherein the phase-out Zone has 9 to 42 tons of steam coal-fired heating boilers 10-35; 18 out of 35 tons of steam table (or a 29 MW) "peaking" heating boiler; built-up area outside the urban area out 10 tons of steam coal 1141 boiler units. Founded out of municipal coal-fired boilers special rectification work to promote the group, environment, housing construction, Industry and Information Department, respectively, to take charge of commercial, heating, industrial three "theater" phase-out of coal-fired boilers. District, county (city) government as the responsible body, one by one out of the implementation of the responsibility to determine the transformation of the way, to promote the phase-out. Gas companies, power companies and projects ahead of docking units, to protect gas, electricity supply and project construction. Planning, construction, urban management, public security and traffic control and other departments to provide maximum support and protection for countersigned examination and approval. Not included in the scope of elimination with 65 tons of steam coal-fired boilers, Harbin through online monitoring, supervision and monitoring, enterprise self-monitoring and "double random a public" supervision and inspection and other means to strengthen supervision, and urge enterprises to strictly enforce existing emission standards for excessive emissions will be punished according to law.
[email protected]