Mill 6 ton coal fired steam boiler for factorys to reduce pollution which method 1, leak checking and maintenance of protection: 2 mm steam leakage will cause energy losses of more than 10 tons of coal each year do? When you do not use it, you can turn it off to save energy. For water, steam and compressed air leak survey and routine maintenance, cost very little. 2, the non-contact cooling water in repeated use: Since the non-contact cooling water temperature and the quality is very good, it can be reused for desizing, scouring, rinsing and other processes. Three best source of cooling water is regenerated: sintering machine, a pre-link and compressor systems. The plant water recovery system may be installed, pipes, valves, storage tanks, and control systems. 3, reuse of steam condensate: textile mills require large amounts of saturated water vapor in the dyeing process, wherein a portion of the condensate is converted to its high temperature and purity. Water can be pumped back to the boiler to form a new steam. For those who buy steam from suppliers, or boiler is located away from the dyeing process, the condensate can be used as water washing or desizing. 4, pre-treated wastewater reuse Procedure collected bleaching, mercerizing machine, the water can be reused in other programs, there is no direct discharge of wastewater. 5, hot wash water is recovered from the hot gas in the dyeing process, large amounts of hot water are used to wash. Heat the washing water can be collected by the system plate heat exchanger to preheat the water to be sent to the next washing. 6, pre-screened coal enterprises should introduce screening spiral coal boiler technology to selection of raw materials. It is possible to improve the media tell the good, the bad quality of proportion, to avoid loss of small volumes of coal and coal calorific value. 7, maintaining steam traps traps can help maintain effective delivery of the steam plant. The valve is removed from the steam pipe and prevent further condensation water, so as to avoid heat loss and reduce fuel consumption. 8, pipe insulation pipes, valves and flanges, valves and flanges experience hot waste of resources, reducing efficiency. Steam delivery device insulated to prevent vapor loss is an inexpensive, energy-saving method of .9, the heat recovery boiler chimney smoke at a temperature of 360 deg.] C, and sometimes directly discharged into the atmosphere, there is no heat recovery. In fact, this heat can be used to preheat boiler water, steam or create a new steam system. 10, optimization of compressed air systems consume a large amount of compressed air in many parts of textile machines Mills. These instruments are prone to leakage, particularly in a threaded joint, rubber joints, valves, automatic regulator, the inflatable device and the old gasket. In addition, the use of compressed air pressure is usually based on the maximum pressure setting; reduce this pressure is feasible and would not have any negative impact manufacturing.
The use of gas 6 ton coal fired steam boiler for factory added to give businesses what benefits? National emphasis on energy conservation increased year by year, which also contributed to the gas steam boiler flourish among industry, under the premise of environmental policies and to efficiency gains, companies are willing to choose both energy-saving, and high thermal efficiency of gas-fired boiler. Gas steam boiler in addition to providing sufficient high-temperature steam, but also can reduce fuel cost by reducing the combustion load input. The use of gas steam boiler will bring any significant benefits, let's take a look. 1, the biggest benefit is the economic use of gas steam boiler can save a lot of fuel costs for businesses, you do not need to spend lots of money to purchase a large amount of coal fuel, just use good cleanliness of natural gas will be able to output enough steam; they also do not We need the fuel storage site, only need to connect to the pipeline. 2, security is well known that natural gas is a very safe and stable, non-toxic and pollution-free, good cleanliness of fuel, liquefied petroleum gas or gas leak after not deposited on the ground, and even cause accidents will burn again. Process gas steam boiler during conveying gas selected gas is the most secure, but also easily found after leakage during use and therefore is the most secure way. 3, convenient gas steam boiler in the use, operation is very convenient, so will much favored by all walks of life. Because the use of all natural gas pipeline, a sustained run without any problems. Eliminating the need to transport coal use and clean-up or stacking cinder and other tedious work. 4. Clean the reason why gas steam boiler in the market to get a high rating, but also because it is clean and not contaminated during use, and does not produce black bottom of the pot, there is no air pollution. Thus, in use, compared to other boiler is the cleanest way.
Wuhan Port District Social Welfare Institute (apartments for the elderly) is invested by the government pension services, with a total construction area of 38,000 square meters, 532 beds, mainly adopt destitute persons, social support on behalf of the elderly. Hope to provide welfare to the elderly year-round 24-hour hot water, the original boiler equipment can not meet this demand, therefore, require additional purchase orphanage hot water boiler. After much investigation, in cooperation with the welfare determined fast boiler, provides three integrally condensing gas hot water boiler (WNS1.4-1.0 / 95/70-Y.Q) by a fast boiler.
Select gas 6 ton coal fired steam boiler for factory What are the benefits? As the state continues to pay attention to energy conservation also contributed to the gas steam boiler flourish among industries, companies are willing to choose high cost of both energy efficient and low thermal efficiency of the boiler as use. Most assured gas steam boiler in addition to providing rapid release of steam heating, but also can reduce fuel combustion load to reduce the input costs of enterprises. The specific choice of gas steam boiler using the benefits of Look Xiao Bian explained below: 1: The biggest benefit is the economic use of gas steam boiler can save a lot of material costs for the business users do not need to spend lots of money to purchase a large amount of coal fuel , only need to use good cleanliness of natural gas can be released by combustion of steam used. Gas can also improve the thermal effect of reducing the material input costs of users. 2: Security is well known that natural gas is the safest non-polluting fuel cleanliness good a non-toxic, unlike gas or liquefied petroleum gas leak after precipitation on the ground will burn even cause accidents. Process gas steam boiler during conveying gas selected gas is the most secure, but also easily found after leakage during use and therefore is the most secure way. 3: convenient gas steam boiler in use is the most convenient one, so will much of each enterprise users of all ages. Are used in natural gas pipelines like the convenience of home tap water, and sustainable use will not be any trouble. Eliminating the need to transport coal use and clean-up or stacking cinder and other tedious work. 4: Clean the reason why gas steam boiler in the market to get a high rating, but also because it is clean and not contaminated during use and does not have the black bottom of the pot and no air pollution. So compared to other boilers in use is the cleanest one way, whether for work or residents of the surrounding operation of the enterprise itself or cleaner can not affect physical and mental health. In summary, the small series is about the use of gas steam boiler of four benefits, the boiler is an important source of power in many businesses also use the state-owned valuable energy channels. Professional gas steam boiler can not only save the country more valuable fuel resources, but also in the use of energy saving and improve exhaust gas air pollution.
[email protected]
